The Sportster and Buell Motorcycle Forum - The XLFORUM®
 

Go Back   The Sportster and Buell Motorcycle Forum - The XLFORUM® > SPORTSTER MOTORCYCLE FORUM > Sportster Motorcycle Suspension, Frame, Forks, Handlebars, Fuel Tank, Oil Tank, Fenders
XLF Blogs XLF Arcade XLF Disclaimer/Privacy Statement/Terms Of Use

Notices

Sportster Motorcycle Suspension, Frame, Forks, Handlebars, Fuel Tank, Oil Tank, Fenders Discuss Sportster Motorcycle Suspension, Frame, Forks, Handlebars, Fuel Tank, Oil Tank, Fenders problems, advice, and/or how tos.

Active Threads
0 Question of rear hub right side spacers (between bearings
Last Post: trappnman
Posted On: 5 Minutes Ago
Replies: 2
Views: 73
0 Mimi the Deerslayer: the triple threat
Last Post: thecarfarmer
Posted On: 7 Minutes Ago
Replies: 44
Views: 3,680
0 Hammer 1275 clang noise, slow oil feed, kinked crankcase vent.
Last Post: Hippysmack
Posted On: 13 Minutes Ago
Replies: 519
Views: 16,548
0 Keep & Kill
Last Post: Graywolf
Posted On: 39 Minutes Ago
Replies: 21,427
Views: 1,265,938
0 Corona Virus
Last Post: Hippysmack
Posted On: 40 Minutes Ago
Replies: 1,663
Views: 161,559
0 Official XL Forum Random Image Thread (NO NUDITY!)
Last Post: Graywolf
Posted On: 40 Minutes Ago
Replies: 50,379
Views: 8,272,765
0 yost power tube guy
Last Post: cazz1000
Posted On: 45 Minutes Ago
Replies: 106
Views: 5,509
0 Iree's late night cafe
Last Post: ~Grind~
Posted On: 1 Hour Ago
Replies: 1,874
Views: 280,422
0 This is gonna hurt.
Last Post: wedge
Posted On: 1 Hour Ago
Replies: 8,457
Views: 1,873,800
0 Bought a 48 with apes
Last Post: AZbiker
Posted On: 2 Hours Ago
Replies: 7
Views: 181
7 Honda Rider
Last Post: Stairman
Posted On: 2 Hours Ago
Replies: 2
Views: 48
0 2018 Iron 1275 Project
Last Post: John Harper
Posted On: 2 Hours Ago
Replies: 34
Views: 3,727
0 Hottie of the day, no nudity.
Last Post: Stairman
Posted On: 3 Hours Ago
Replies: 28,431
Views: 3,028,460
0 WTB 04-06 intake manifold
Last Post: Randy_rots
Posted On: 3 Hours Ago
Replies: 17
Views: 433
0 Oil pressure stays up 20min after shut of
Last Post: Hippysmack
Posted On: 3 Hours Ago
Replies: 11
Views: 400
0 Hawkeye's 1275 Hammer Performance Conversion
Last Post: warsawleague
Posted On: 4 Hours Ago
Replies: 75
Views: 6,341
0 Magneto Sportster's 1964 XLH Restoration Project
Last Post: Steve9
Posted On: 4 Hours Ago
Replies: 63
Views: 8,205
0 Plane crash lands during Cocoa Beach Air Show
Last Post: IXL2Relax
Posted On: 5 Hours Ago
Replies: 2
Views: 81
0 Non-Starter, Compression Test Results
Last Post: Ferrous Head
Posted On: 5 Hours Ago
Replies: 25
Views: 1,212
0 Backfiring
Last Post: David Kirkha
Posted On: 5 Hours Ago
Replies: 38
Views: 2,265
3 Wtb, Wts, Wtt, Wtg (Evos)
Last Post: Folkie
Posted On: 6 Hours Ago
Replies: 3
Views: 85,194
3 Wtb, Wts, Wtt, Wtg (Ironhead)
Last Post: Folkie
Posted On: 6 Hours Ago
Replies: 10
Views: 277,799
0 KT - 2021 - You're In It Now
Last Post: sportsterpaul
Posted On: 6 Hours Ago
Replies: 22
Views: 2,208
0 Stock 48 Handlebars Wanted
Last Post: DéDé
Posted On: 6 Hours Ago
Replies: 1
Views: 41
0 PLEASE READ THIS Before You Post In 'The BUY - SELL - TRADE Zone'!
Last Post: Folkie
Posted On: 7 Hours Ago
Replies: 1
Views: 497
0 BEWARE Of SCAMMERS!
Last Post: Folkie
Posted On: 7 Hours Ago
Replies: 1
Views: 613
0 Getting Out The Wrenches (was: Broken Exhaust Stud)
Last Post: ParrotHead
Posted On: 9 Hours Ago
Replies: 620
Views: 72,824
0 What did you do to your EFI Sporty today?
Last Post: ParrotHead
Posted On: 9 Hours Ago
Replies: 4,007
Views: 828,095
0 2002 XLH1200C what foot controls are stock
Last Post: AZbiker
Posted On: 12 Hours Ago
Replies: 2
Views: 135
0 ....1
Last Post: Graywolf
Posted On: 14 Hours Ago
Replies: 6,035
Views: 357,856
More...
Members Birthdays
Reply
 
Share Thread Tools Display Modes
  #31  
Old 7th February 2021
Jerry P Jerry P is offline
Biker
 
Join Date: Dec 2020
Location: Central Florida
Posts: 46
Sportster/Buell Model: XL1200C
Sportster/Buell Year: 2005
Sportster/Buell Model #2: 2005 XL1200C
Other Motorcycle Model: Yamaha Classic V Star
Other Motorcycle Year: 2005
Reputation: 10
Jerry P is an unknown quantity at this point
Default

BKB, I took your advice and will receive new Progressive 412 shocks Wednesday

At 232 lbs solo, I'm getting 13.5" heavy duty springs, as you suggested

Seems $260 shipped price is cheap way to save my 80 year old lower back.....lol

Man, after 30 non Harley bikes, I LOVE to ride '05 XL1200 Custom
Reply With Quote
  #32  
Old 11th February 2021
BKB's Avatar
BKB BKB is offline
XL FORUM TEAM MEMBER
 
Join Date: Nov 2005
Location: North cental Ohio
Posts: 2,409
Sportster/Buell Model: XL1200C
Sportster/Buell Year: 2009
Sportster/Buell Model #2: XL1200L
Sportster/Buell Year #2: 2009
Reputation: 4813356
BKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond reputeBKB has a reputation beyond repute
Default

By the way, if the heavy duty springs are still to harsh, Progressive does sell just the springs. I recommended the h-d springs so as to prevent bottoming out on the bad bumps at your weight. I know for myself, at 71 years old & arthritic, that jolt of bottoming is worse than a slightly stiff ride that can be softened a bit with tire pressure &/or lowering the preset of the springs.
__________________
Brian '09 1200C (black of course), 19" front wheel, det. windshield, Sundowner, mini apes, Big Sucker, 12.5" Progressive 412's, Intiminators, Gronk mod
I didn't buy a Sportster 'cause I wanted a Harley... I got a Harley 'cause I wanted a SPORTSTER!!!
Reply With Quote
  #33  
Old 12th February 2021
Jerry P Jerry P is offline
Biker
 
Join Date: Dec 2020
Location: Central Florida
Posts: 46
Sportster/Buell Model: XL1200C
Sportster/Buell Year: 2005
Sportster/Buell Model #2: 2005 XL1200C
Other Motorcycle Model: Yamaha Classic V Star
Other Motorcycle Year: 2005
Reputation: 10
Jerry P is an unknown quantity at this point
Default

BKB, gotta thank you man

Installed new Progressive 412 shocks with HD springs, 13.5" with help from my friends yesterday.

Pretty easy and straightforward to do. Raised bike up about an inch (perfect for my height) and not too bad a more aggressive lean on side stand

Rode around park and noticed immediate smoother ride

Will get out on road and really test em out today and report back

Thanks BKB. You steered me in the right direction

BTW I haven't changed pre-load setting yet but, dumb question, which way (up or down) should I adjust to get just a bit softer ride?
Reply With Quote
  #34  
Old 12th February 2021
TowPro TowPro is offline
Biker
 
Join Date: Dec 2020
Posts: 20
Sportster/Buell Model: not yet
Sportster/Buell Year: 2006
Reputation: 10
TowPro is an unknown quantity at this point
Default

the progressive site says you should set preload so center to center on mount bolts is 12.25" with your weight on bike. Same if your fully loaded with passenger and luggage, 12.25"

Target Ride Length (in) : 12.25
Target Ride Length is the length of the selected shocks, installed, and as measured between the upper and lower shock mounts ***, when the full weight of the rider(s) & gear are on the bike and ready to ride. This is a fast and easy way to set your rear suspension at optimum Ride Sag (1/3 of total suspension travel)
Reply With Quote
  #35  
Old 12th February 2021
SLW210's Avatar
SLW210 SLW210 is offline
Flat Track Champion
 
Join Date: Jun 2017
Location: Near Ft. Myers
Posts: 646
Sportster/Buell Model: 1200C
Sportster/Buell Year: 2009
Sportster/Buell Model #2: FXLR Low Rider
Sportster/Buell Year #2: 2019
Reputation: 1171193
SLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond repute
Default

I wouldn't lower tire pressure for a softer ride. Bad idea. Could lead to premature (and catastrophic) tire failure among other things.
Reply With Quote
  #36  
Old 14th February 2021
Jerry P Jerry P is offline
Biker
 
Join Date: Dec 2020
Location: Central Florida
Posts: 46
Sportster/Buell Model: XL1200C
Sportster/Buell Year: 2005
Sportster/Buell Model #2: 2005 XL1200C
Other Motorcycle Model: Yamaha Classic V Star
Other Motorcycle Year: 2005
Reputation: 10
Jerry P is an unknown quantity at this point
Default

Went back to 36 psi in rear tire

Clicked 2 notches of pre-set (counter clockwise) to soften ride

Anxious to try her out if rain stops, that is

With heavy duty springs, I might have to go another notch of pre-set to further soften ride.

Thanks much for your help guys. I'll report back after rain stops
Reply With Quote
  #37  
Old 2nd March 2021
Jerry P Jerry P is offline
Biker
 
Join Date: Dec 2020
Location: Central Florida
Posts: 46
Sportster/Buell Model: XL1200C
Sportster/Buell Year: 2005
Sportster/Buell Model #2: 2005 XL1200C
Other Motorcycle Model: Yamaha Classic V Star
Other Motorcycle Year: 2005
Reputation: 10
Jerry P is an unknown quantity at this point
Default

Guys, maybe it's my age or my lower back, but I gave up with this fine bike

Even with new Progressive 412 shocks tested at every pre-load notch, my lower back hurt

So on Feb 27, I sold this fine bike

Thanks so much for all of your help and advice.

I sure did appreciate all of ya and am gonna now go over to the Kaw Vulcan forum for help with my new to me (2014) ride (900 cc's, belt driven, fuel injected, mono shock 600 lbs, liquid cooled with only 4000 miles). I celebrate 80 years on Mar 6. Good to have been with you all.

Jerry
Reply With Quote
  #38  
Old 3rd March 2021
SLW210's Avatar
SLW210 SLW210 is offline
Flat Track Champion
 
Join Date: Jun 2017
Location: Near Ft. Myers
Posts: 646
Sportster/Buell Model: 1200C
Sportster/Buell Year: 2009
Sportster/Buell Model #2: FXLR Low Rider
Sportster/Buell Year #2: 2019
Reputation: 1171193
SLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond reputeSLW210 has a reputation beyond repute
Default

Good luck.

My 80 year old neighbor said he's been looking to get back on a motorcycle. He looked at a V-Star, he said it seemed heavy to him, so he's going to look at smaller bikes.

He said his wife said she was going to leave him if he got a motorcycle. He says he is definitely getting a motorcycle now.
Reply With Quote
  #39  
Old 4th March 2021
Jerry P Jerry P is offline
Biker
 
Join Date: Dec 2020
Location: Central Florida
Posts: 46
Sportster/Buell Model: XL1200C
Sportster/Buell Year: 2005
Sportster/Buell Model #2: 2005 XL1200C
Other Motorcycle Model: Yamaha Classic V Star
Other Motorcycle Year: 2005
Reputation: 10
Jerry P is an unknown quantity at this point
Default

SLW210, thanks man

Tell your 80 year old neighbor to go ahead and get that V Star

This 80 year old is really enjoying 700 Lb Kawasaki and is keeping great wife (best ever) too. Three of us (Kaw, Harley & Yam) were out this pm on 50 mile run in 80 degree Florida sun and since I am senior, I get to lead, an honor indeed.

Jerry
Reply With Quote
  #40  
Old 5th March 2021
Ranchero50's Avatar
Ranchero50 Ranchero50 is offline
Senior Chief Master Mechanic 2nd Class
 
Join Date: Aug 2014
Location: Hagerstown MD
Posts: 1,587
Sportster/Buell Model: 1200 Street Brawler
Sportster/Buell Year: 2005
Reputation: 1066193
Ranchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond reputeRanchero50 has a reputation beyond repute
Default

Custom shocks are too tight. For the next poor guy, the '03 sport shocks work well but you also need a longer kickstand from a rigid mount. Absolutely love how mine handles.
__________________
The build thread... http://xlforum.net/forums/showthread.php?t=1821880
Reply With Quote
Reply

Bookmarks


Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump



All times are GMT +1. The time now is 02:39.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2021, vBulletin Solutions Inc.
XL Forum® - Linson Media LLC