The Sportster and Buell Motorcycle Forum - The XLFORUM®
 

Go Back   The Sportster and Buell Motorcycle Forum - The XLFORUM® > SPORTSTER MOTORCYCLE FORUM > Sportster Motorcycle Electrical > Sportster Motorcycle Electrical and Ignition
XLF Blogs XLF Arcade XLF Disclaimer/Privacy Statement/Terms Of Use

Active Threads
0 Riding in the rain
Last Post: 60Gunner
Posted On: 48 Minutes Ago
Replies: 129
Views: 26,891
0 Full face, Half or skull cap?
Last Post: mikeLI_77
Posted On: 1 Hour Ago
Replies: 502
Views: 93,364
0 Anti reversion “muffler”
Last Post: Tomcatt
Posted On: 2 Hours Ago
Replies: 32
Views: 1,467
0 If You Have An '04+ (Buell's too), Please Read (Oil Usage)
Last Post: JaKaL
Posted On: 3 Hours Ago
Replies: 152
Views: 23,307
0 Still got your upper drive belt guard??
Last Post: Ireeman
Posted On: 3 Hours Ago
Replies: 111
Views: 19,460
0 MPG HONESTLY, what do you get?
Last Post: a-sad-anorak
Posted On: 3 Hours Ago
Replies: 579
Views: 76,190
0 Keep & Kill
Last Post: Crusty
Posted On: 4 Hours Ago
Replies: 14,320
Views: 804,380
0 ....1
Last Post: toe
Posted On: 5 Hours Ago
Replies: 5,000
Views: 296,205
0 question about new trans door
Last Post: Iron Mike
Posted On: 5 Hours Ago
Replies: 10
Views: 184
0 XL IR EFI to those that asked
Last Post: Iron Mike
Posted On: 5 Hours Ago
Replies: 24
Views: 1,075
0 98 Stator Removal / Inspection / Installation
Last Post: 60Gunner
Posted On: 6 Hours Ago
Replies: 17
Views: 596
0 This week on Craig's list
Last Post: IXL2Relax
Posted On: 7 Hours Ago
Replies: 4,455
Views: 544,341
0 Crusty's Travels
Last Post: Davo_137
Posted On: 7 Hours Ago
Replies: 2,588
Views: 341,620
0 Multiple timing marks?
Last Post: needspeed
Posted On: 7 Hours Ago
Replies: 35
Views: 19,086
0 Where were the IronHead sportsters Made.
Last Post: NLXL
Posted On: 8 Hours Ago
Replies: 8
Views: 371
0 Hottie of the day, no nudity.
Last Post: Stairman
Posted On: 10 Hours Ago
Replies: 15,022
Views: 1,422,652
0 Hot Chicks on Hot Bikes
Last Post: trainman
Posted On: 10 Hours Ago
Replies: 10,385
Views: 1,819,036
0 BMW reverse trike build
Last Post: Stairman
Posted On: 11 Hours Ago
Replies: 4
Views: 148
0 Cometic Valve Stem Seal Install?
Last Post: BlackBikeDave
Posted On: 12 Hours Ago
Replies: 12
Views: 225
0 diagnose noise in engine after rebuild
Last Post: Nibelungen
Posted On: 14 Hours Ago
Replies: 13
Views: 491
0 Handlebars
Last Post: decman
Posted On: 14 Hours Ago
Replies: 2
Views: 122
0 .551 Cams in an EFI 1200
Last Post: Tomcatt
Posted On: 14 Hours Ago
Replies: 76
Views: 4,518
0 Roads I'd like to ride.
Last Post: Stairman
Posted On: 15 Hours Ago
Replies: 2,573
Views: 219,474
0 Best Battery Maintainer and/or Booster?
Last Post: stikflote
Posted On: 15 Hours Ago
Replies: 29
Views: 1,158
0 1200 conversion
Last Post: Folkie
Posted On: 16 Hours Ago
Replies: 2
Views: 137
0 Do you blip the throttle when downshifting?
Last Post: 60Gunner
Posted On: 17 Hours Ago
Replies: 462
Views: 79,868
0 Derby cover
Last Post: RussW
Posted On: 18 Hours Ago
Replies: 5
Views: 164
0 THE Hockey Thread
Last Post: XL Ed
Posted On: 19 Hours Ago
Replies: 4,038
Views: 270,383
0 Iree's late night cafe
Last Post: Maxeffort
Posted On: 19 Hours Ago
Replies: 1,335
Views: 169,949
More...
Members Birthdays
vlmuke, wazza (48), Grizzwold (44), roaldtm (39), redtacoma31 (34)
Sponsored Links
Reply
 
Share Thread Tools Display Modes
  #21  
Old 4 Weeks Ago
sportsterdoc's Avatar
sportsterdoc sportsterdoc is offline
Senior Master Custom Bike Builder
 
Join Date: Apr 2012
Location: Mojave Desert
Posts: 13,392
Sportster/Buell Model: 1200S
Sportster/Buell Year: 2002
Sportster/Buell Model #2: XLH883
Sportster/Buell Year #2: 2003
Reputation: 5766646
sportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond repute
Default

Quote:
Originally Posted by Coop802 View Post
Why no more than 2.8 quarts? I should probably change the filter too so I would need a bit more to cover the filter capacity.
Go about 1/3 down this Sportsterpedia link or in the link search 2.8

http://sportsterpedia.com/doku.php/techtalk:refil01?s[]=oil&s[]=capacity

You may also find this intetesting

http://sportsterpedia.com/doku.php/techtalk:evoil01
Reply With Quote
  #22  
Old 4 Weeks Ago
sportsterdoc's Avatar
sportsterdoc sportsterdoc is offline
Senior Master Custom Bike Builder
 
Join Date: Apr 2012
Location: Mojave Desert
Posts: 13,392
Sportster/Buell Model: 1200S
Sportster/Buell Year: 2002
Sportster/Buell Model #2: XLH883
Sportster/Buell Year #2: 2003
Reputation: 5766646
sportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond repute
Default

Quote:
Originally Posted by Toejam503 View Post
Most of us have found out, over the years, that 2.6qts -2.8qts works best to keep oil from flowing out of the top of the oil tank or being pushed out the breathers as the engine gets hot and during high RPM. The newer manuals finally adjusted the oil amount to 2.8qts on an oil change.
And the early rubster manual was simply incorrect as referenced in the Sportsteria link.

If filled to full mark on my 1200 Sport, a 1-2 hour ride would self-level to the 1/2 way mark.

From Sportsterpedia

Tech Tip #312 - 6/15/07 - Quote: 2004-2007 Sportster Oil Capacity - Service literature for 2004-2007 XL models incorrectly lists oil capacity as 3.6 quarts (3.4 liters). The correct amount listed should be 2.8 quarts (2.65 liters). Oil capacities listed are approximately the amount required to bring the fluid level near the full mark on the dipstick. Service Note: Be aware that the dipstick has a Full mark to indicate the highest level of oil that should be installed in a hot engine and an Add mark to indicate the lowest level of oil in a cold engine. The engine is designed to operate correctly with the oil level in the range between these two marks. While it is most important to not overfill the system, it is acceptable to operate the motorcycle with the oil level anywhere in the range between the Full and Add marks. 64) (This may be oil change only without the filter.)
Reply With Quote
  #23  
Old 3 Weeks Ago
Coop802 Coop802 is offline
Biker
 
Join Date: Oct 2019
Posts: 9
Sportster/Buell Model: xl1200c
Sportster/Buell Year: 05
Reputation: 10
Coop802 is an unknown quantity at this point
Default

I really appreciate the help.

Just an update:

I was able to find the source of the original short, the speedometer. I dis-assembled the speedo but was unable to find any obvious signs of shorting. Once I disconnected from the harness the bike stopped blowing the batt fuse.

I went through the car and it was pretty clean. A little tarnish but I was able to clear it all with carb cleaner and flushed all orafices. I replaced it and the bike is ready to try and start. I plan on cranking it this afternoon, then doing the oil change. Fingers crossed!

Is there a thread on acceptable oils and filters I should read before asking? I asked the dealer but he simply avoided the question. $78 each oil change is pretty hefty.
Reply With Quote
  #24  
Old 3 Weeks Ago
Toejam503's Avatar
Toejam503 Toejam503 is offline
Air-Cooled Forever
 
Join Date: May 2010
Location: Dakota Territory
Posts: 2,755
Sportster/Buell Model: XL 1200 C
Sportster/Buell Year: 2006
Sportster/Buell Model #2: (Prev.Own)XLH Milw.Spec.
Sportster/Buell Year #2: 1981
Reputation: 5023359
Toejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond reputeToejam503 has a reputation beyond repute
Default

There are so many "oil threads" on here, it borders on ridiculous. I say buy what's affordable, and you are comfortable with, and what's easily and readily available. When you've decided on what you'd like to use, read up on it, on the internet. If it sounds good, use it.
Reply With Quote
  #25  
Old 3 Weeks Ago
sportsterdoc's Avatar
sportsterdoc sportsterdoc is offline
Senior Master Custom Bike Builder
 
Join Date: Apr 2012
Location: Mojave Desert
Posts: 13,392
Sportster/Buell Model: 1200S
Sportster/Buell Year: 2002
Sportster/Buell Model #2: XLH883
Sportster/Buell Year #2: 2003
Reputation: 5766646
sportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond repute
Default

I used Castrol in 14/17 bikes.
The exceptions were Motoul 10W60 in the 2016 Moto Guzzi and H-D 360 in both Sportsters.
The H-D 360 was available and priced competitive at the local dealers.
Otherwise I would have used Castrol in the Sportsters.

Good points by Toejam...any major brand, the appropriate weight for local temperatures and suitable API rating.
Reply With Quote
  #26  
Old 3 Weeks Ago
Coop802 Coop802 is offline
Biker
 
Join Date: Oct 2019
Posts: 9
Sportster/Buell Model: xl1200c
Sportster/Buell Year: 05
Reputation: 10
Coop802 is an unknown quantity at this point
Default

I was able to crank the bike up. Thought I had a bigger problem at first as I forgot to hookup the vacuum line to the petcock, but once I figured that out and primed the carb, the bike started and idled. The bike really didn't puke oil everwhere however. Ill run it some more today before changing the oil.
Reply With Quote
  #27  
Old 3 Weeks Ago
Jollly Rogers Jollly Rogers is offline
Chief Master Mechanic
 
Join Date: Jun 2014
Location: Northeastern West Virginia
Posts: 486
Sportster/Buell Model: 883 custom
Sportster/Buell Year: 2006
Reputation: 734393
Jollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond reputeJollly Rogers has a reputation beyond repute
Default

Quote:
Originally Posted by harley506d View Post
That's good to know.
I am hoping at some future point to get one of the speedo/tach combi unit's, and i see that you get a cable in the kit to transfer data. So it makes sense now.
I wanted a tach on my 06 Custom and got the combo unit from the MoCo. I’m very happy with it. If a tach is a priority, go for it.
Joe
Reply With Quote
Sponsored Links
  #28  
Old 3 Weeks Ago
Coop802 Coop802 is offline
Biker
 
Join Date: Oct 2019
Posts: 9
Sportster/Buell Model: xl1200c
Sportster/Buell Year: 05
Reputation: 10
Coop802 is an unknown quantity at this point
Default

Quote:
Originally Posted by Jollly Rogers View Post
I wanted a tach on my 06 Custom and got the combo unit from the MoCo. I’m very happy with it. If a tach is a priority, go for it.
Joe
Whats the MoCo? (I'm a newb) and when you say Combo unit do you mean the dual guage setup or the guage that has the small tach in the lower right? I saw some like that and didnt think they would fit the 4" mount.
Reply With Quote
  #29  
Old 3 Weeks Ago
sportsterdoc's Avatar
sportsterdoc sportsterdoc is offline
Senior Master Custom Bike Builder
 
Join Date: Apr 2012
Location: Mojave Desert
Posts: 13,392
Sportster/Buell Model: 1200S
Sportster/Buell Year: 2002
Sportster/Buell Model #2: XLH883
Sportster/Buell Year #2: 2003
Reputation: 5766646
sportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond reputesportsterdoc has a reputation beyond repute
Default

MoCo (motor company) = H-D = Harley-Davidson
Reply With Quote
Reply

Bookmarks


Currently Active Users Viewing This Thread: 1 (0 members and 1 guests)
 
Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump



Sponsored Links
All times are GMT +1. The time now is 09:41.


Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2019, vBulletin Solutions Inc.
XL Forum® - Linson Media LLC