View Full Version : Sportster Motorcycle Transmission, Clutch, Primary & Secondary Drive


Pages : 1 2 3 4 [5] 6 7

  1. Will these rear sprocket/pulley spacers fit an 06
  2. Locating a rear chrome sprocket for an 06
  3. Comparrision of gear ratio.
  4. Not shifting properly
  5. Pully size options?
  6. pros and cons of swithcing to a chain drive
  7. offset front sprocket????
  8. Attn all 1200 Canadians
  9. chain size....
  10. 1980 Ironhead trans. problem
  11. 1994 XL Tranny problem
  12. 2001 sporty drive belt
  13. Help! - Strange noise on left side
  14. Gearshift Shaft
  15. Best replacement clutch?
  16. Changing transmission fluid
  17. need some clutch cable advice
  18. Engine sprocket nut size?
  19. My ring gear came loose
  20. Ran my bike with no transmission oil
  21. Advice for a preformence clutch
  22. Clutch spring plate grenaded!
  23. need info on what sprocket setup to use
  24. 5 Speed In A 4 Speed Frame???
  25. Primary/Tranny ????
  26. installing new clutch
  27. 3rd Gear
  28. Longer belt ????
  29. Auto trans fluid
  30. Custom Derby Cover I had done
  31. Rubbermount rear pulley on a pre 2004?
  32. clutch !!!!!!!*ed
  33. muller power clutch
  34. Custom Shifters
  35. jockey shift
  36. forward controls?
  37. open primary
  38. Down to 1 inch for 07 and up?
  39. Another clutch ?
  40. Thinking of going to 28/70 on the 1200
  41. Primary gasket leak with new gasket
  42. Stator ?
  43. Pulley Change/ Speedo
  44. Derby Cover and Timing Cover
  45. Drive chain???
  46. Clutch Line Tough to Pull Sometimes 2000 883
  47. Got my Forward Controls today
  48. Primary Cover Gasket
  49. Front secondary 29t pulley for a S1, M2, X1, fit my sporty??
  50. Primary Metal Fuss: How much is too much?
  51. Trick to getting forward pulley off?
  52. Inside the Primary Cover
  53. suicide shift kits
  54. cable questions
  55. HELP-- fourth gear GONE??!
  56. Main Shaft First Gear removal
  57. clutch cable
  58. long belt size
  59. clutch cable???
  60. I think it's bull
  61. '03 and down rear pulleys
  62. changed the derby cover now clutch wont disengage ????
  63. Safe running w/o sprocket cover?
  64. Does this gear need to be replaced?
  65. 29 tooth pulley /speedometer
  66. lube a drive belt?
  67. Complete Clutch for 84 Sport Ironhead
  68. Any tips?
  69. foot clutch/handshift, or hand/hand??
  70. How do you get the transmission output shaft through the seal
  71. 2002 883c stuck in fifth after a fall
  72. mainshaft oil seal replacement.
  73. chain guard(not belt)
  74. I'm boned, and don't know what to do next. Help!
  75. Jockey Shift! HELP!
  76. -6 Sporty 02' clutch cable
  77. Convert chain to belt 1986 xlh 883
  78. Rear Sprocket belt drive?
  79. Drive belt pulley spacer?
  80. I just need some Help
  81. clutch release problems
  82. Swingarm Extension?
  83. clutch won't release
  84. Need help
  85. Rear pulley teeth for a spoortster 1200 born in 1993
  86. Notes on changing front pulley on rubber mounts.
  87. 20mm belt
  88. Cracked case behind trapdoor
  89. gear selection problems
  90. Dry clutch?
  91. 75 Ironhead Rebuild Stuck In Gear
  92. Best Choice for Axle Material
  93. Problem with my gears?
  94. 07 front sprocket vs 06
  95. Rotor magnets
  96. Sprocket Help
  97. open primary 57 - 66 sportys
  98. no trapdoor
  99. foward controls to mid mount
  100. Convert to early 4 speed
  101. 04 up open belt drive primary
  102. Trap door
  103. sportster clutch
  104. kickstart for evo?
  105. xlch 3rd gear chatter
  106. Clutch adjustment under derby cover?
  107. Finally got after it
  108. Can any one help with engine balancing?
  109. How to lube a clutch cable
  110. New clutch
  111. Starter gear ring fell off.
  112. Clutch Problems....
  113. Putting mid-controls on a Custom
  114. front pully...
  115. Clutch Slip
  116. need info on oil drain line under motor 96 sporty
  117. need 2 quick anwsers...
  118. Primary cover removal '86 xlh883
  119. Oil change after winter storage
  120. Strange drive belt problem
  121. Easy Clutch
  122. Drive belt alternatives for emergencies
  123. can i convert an electric speedo to a mechanical?
  124. missed shift 3rd gear - frequent
  125. Replacing Clutch - Need new o-ring?
  126. Clutch Adjustment Help.....
  127. MRC CLUTCH effort reduction kit
  128. Belt adjustment!!!
  129. Best place to get Zipper's billet transmission door for 4 speed...
  130. Chain Drive
  131. Need help for repacementt parts for a Trak-Tech chain conversion?
  132. Clutch Master Cylinder
  133. primary plug leak
  134. Clear primary covers
  135. Forward Controls for a 1988??
  136. RPM difference for a primary gear change
  137. new sprocket cover
  138. what size is the rear shock Torx bolt on a 07?
  139. 4 speed door replacement
  140. trans fluid substitute?
  141. trouble with derby cover
  142. Is some belt noise normal?
  143. Max power on stock clutch/belt?
  144. Primary Chain Snatches ?
  145. Jockey Shift
  146. Groove in belt
  147. Where did the Primary & Transmission oil go?
  148. 03 sporty gear problems
  149. AMP E-Z Pull Clutch
  150. Shift linkage broken??!
  151. Installing a new chain
  152. 4 speed to 5 speed conversion
  153. Have you changed from 61 to 55 tooth?
  154. Forward controls a serious aggravation!!!
  155. 06 1200 rear sprocket / belt noise
  156. Chopped Cam Cover
  157. Chainsikle rearsets for sale
  158. Primary fluid change
  159. Gearing ratios need some help!
  160. primary cover
  161. mystery part ?
  162. Shifter parts part no's
  163. chain conversion??
  164. 1200C Trans shift prob
  165. primary lube?
  166. 74 XLH Won't Stop cranking again.
  167. Shifter Detent Plate Installation
  168. Transmission Gear Question
  169. Stock chain links
  170. Knuckle cracking sound from primary
  171. front pulley
  172. Need rocker clutch for 2006 Sportster 1200 Custom
  173. Primary Oil Change Question
  174. removing primary cover
  175. Stiff clutch
  176. How do I change my Clutch Cable?
  177. jockey shift question
  178. help: Clutch Cable Popped Off
  179. T-Bars and Clutch Cable Change
  180. What shift fork?
  181. Mid controls?
  182. sticky gear lever
  183. drive belt jerking engine backwards????
  184. Clutch Issues!!!!!
  185. Primary Oil how much?
  186. Question for 883 owners with a Tach
  187. Grinding gears? Normal?
  188. Clutch sugestions
  189. D.I.D. chain ?????
  190. Part Number Help
  191. shifter lever arm replacement
  192. Clutch squark, squeal
  193. What the hell is this?????
  194. final drive belt Question plese help
  195. 1st gear/ transmission advice needed
  196. What can I do .
  197. lost 4th gear what to expect?
  198. damn drive belt... broke! chain conversion?
  199. Oil out of the clutchcable?
  200. Spitting oil from Transmition vent.
  201. Chain Drive Conversion for Rubber Mount XL
  202. Clutch cable replacement.?.? Installing APES!!!
  203. Clutch Hub nut question
  204. Oil from clutch cable...
  205. Anyone have to change a primary chain yet?
  206. Is it slipping?
  207. ZIPPERS CHAIN conversion HELP!!!!
  208. '07 Primary cover same as '06?
  209. Funny thing happened on the last road trip
  210. Clutch won't disengage
  211. 2002 shifting problem - clutch or transmission?
  212. only 1st and 2nd gear tranny broke
  213. stock clutch from a 883 used in a 1242
  214. Strange slipping sound in primary
  215. Ok I'm Stupid!!!!!!!!!!!!
  216. hydraulic clutch
  217. Extreme Custom Engraving Billet Derby Covers
  218. clunkin shifts
  219. broken spring behind shifter peg assembly...couple q's
  220. Oil Change
  221. 55tooth help
  222. Shifter won't return for 2nd to 1st downshift
  223. Tranny or clutch prob?
  224. Forward controls Price - WTF????
  225. Trans Gear Teeth...
  226. Chain coversion ?
  227. Has anyone replaced their sporty transmission?
  228. I have no clue....?
  229. Need a measurement!!!!
  230. Stiff clutch lever
  231. Rigid_EVO Here is the symptom, whats the cure?
  232. 1995 1200, trans fluid
  233. 1986 883 clutch problem
  234. Fixing Brass Points Covers
  235. Blown a clutch? Please give details....
  236. main shaft nut
  237. Always in gear ..
  238. Primary/ Trans breather hose leaking
  239. Rubbermount_EVO Gear Shift Lever Position
  240. Stupid mistake, will I be ok?
  241. 3rd sometimes slips or hesitates ???
  242. trap door vs new setup?
  243. 3rd gear issues!?!?
  244. Transmission pulley cover
  245. Problem when shifting down
  246. Help ! Part number needed !
  247. 21/47 chain drive
  248. Leftside laydown, clutch won't disengage
  249. Rubbermount_EVO Clutch Weirdness !
  250. Need help finding chart on sprocket sizes