View Full Version : Sportster Motorcycle Transmission, Clutch, Primary & Secondary Drive
Pages :
1
2
3
4
5
[
6]
7
8
9
10
11
12
- Popping the Clutch
- How I got my transmission pulley off in 5 minutes with my broken belt
- Primary Cover Bolt Torque Specs
- Help, belts, which one? BDL, Panther, Gates, HD, ...?
- clutch cables....interchangable?
- Primary chain adjustment starting point after cover has been replaced?
- Rigid_EVO Problem with clutch maybe?
- need help with final drive ratio
- Plug behind the primary??
- Which Clutch Cable
- 5 spd 3rd gear replacement problem
- Belt teeth shearing off!?
- popping in and out of first gear
- Automatic Clutch?
- Clutch Compression Plate...or not?
- Ironhead Primary noise
- this friggin sucks, need help witha primary question
- Rubbermount_EVO Secondary Drive Belt Rubbing on Cover
- 2008 chain noise
- Stock Rubbermount Tranny Limits?
- Rubbermount_EFI Re-gearing my 1200
- whats the difference between the xring and oring chain
- Help changing primary oil
- Bike moves forward (when its not wanted)
- Easy Pull
- Transmission Gear Ratio's - Hot Street Poll
- Recall for transmission issue.
- 1993 sportster 1200 conversion with a 27/70 what size belt do I need?
- Will this pulley work 61 tooth 1 1/2wide on 96 sporty
- drive belt
- Clutch
- 6 speed transmission upgrade...?
- 5 speed conversion
- Clutch rattle
- Chain conversion 2008?
- Ironhead Transmission Removal
- Rigid_EVO Talkingwalking
- Clutch drag with barnett extra plate
- Loud Trans clunking noise
- Slight grind into first
- Ironhead Ironhead tranny jumping out of first
- Rigid_EVO Raising the gearing, 1990 chain drive Sporty
- Clutch stiffening up
- help needed
- Rubbermount_EVO Drive belt difference?
- Drive belt
- So I lost 4th gear today, few ?
- what clutch brand is the best
- Clutch tool... How the heck does this thing work?
- lube question
- primary inspection port
- Rattling or pinging by the primary
- rod knock or primary?
- Primary fluid level.
- Clutchless Shifting
- Pucking primary--Help
- Slipping out of 4th
- Ironhead Primary gushing oil
- Vent tube issue?
- Rigid_EVO 1992 trans
- Better to change rear pulley or front pulley?
- Do you check your primary fluid level?
- Derby cover blues
- barnet clutch plates and discs
- Rigid_EVO Transmission won't down shift
- A close one...
- Rigid_EVO impact hammer
- 2000 XLH with clutch noise when engaged
- Rigid_EVO andrews gears
- Rubbermount_EVO Mïssïng Tee†h øn Ðrïve ßel† [3-pïcs]
- laid bike down, tranny screwed?
- 883R 1st gear problem
- Rigid_EVO Clutch "snatching" after routine maintenance
- Rubbermount_EVO Clutch not engaging fully
- gearsXhoresepower
- clunking/grinding noise going into 1st
- First repair job complete!
- belt drive to chain conversion
- Clutch /cable adjustment problem
- Rubbermount_EFI Identify this noise...
- argh - 87 evo sporty pulley nut - right or left hand thread
- sportster 6th speed overdrive
- Chain Conversion Sprocket
- Rigid_EVO 1988 Gearbox Rebuild
- New Primary Inspection Cover
- Evil !!!!!!!!! sound!
- Drive Belt Options?
- Rubbermount_EVO Big Twin Pulley on an '06 1200
- Rubbermount_EVO Rekluse Clutch
- Revloc Clutch vs. Pingel Easy Shift
- Rubbermount_EVO Energy one clutch installation
- Rubbermount_EVO Anyone Got a Big Twin?
- Chain Questions/ Nd Faq
- Criteria for measuring pulley wear?
- Gearcase gasket replacement
- evo or ironhead countershaft clarification reqd
- Broken Secondary Drive Belt
- Rigid_EVO 1st gear doesn't engage
- Chroming the gear covers
- Back to the drawing board...
- Secondary Drive belt
- Rubbermount_EVO 02 transmission mainshaft free play
- Clutch Replacement
- 125T Dayco Panther Belt
- Belt to Chain Conversion
- Rigid_EVO possible tranny issues?
- Rubbermount_EVO Looking for some visual help
- Cam Cover
- Rigid_EVO Transmission fill plug...
- clutch slipping
- open primary
- play in clutch hub
- how tight should these be ?
- Checked compensator nut tension today.
- primary cover gasket change yes or no ???
- Rubbermount_EVO rattle noises/ ticking
- replaced the drive belt...
- Sprocket locking link
- drive sprocket replacement
- re red loctite 262
- Refil through primary inspection port?
- Primary cover spacer ????
- Can anyone help please ?
- Primary case pipe to be Identified ???
- Clutch Engagement
- Streaching things.
- Shifter Problems...
- Clutch adjustment again!?
- Rigid_EVO new to the forum and confused?
- Looking for derby cover for R&D
- Rookie question about the primary gasket
- Shift Shaft replacement
- sprotor question
- stock cable length
- Rigid_EVO A Big Thanks!
- clutch spring compressor
- Clutch Cable Routing
- primary case screws/bolts
- Most reliable drive type?
- Clutch life and city driving.
- transmission drain plug question.
- 04 sprocket on 98?
- Rubbermount_EVO Too much swarf?
- Adjusting gear shift lever
- Best four speed clutch ( big power)
- Belt pulley cover install
- pulley change
- tear down rebuild
- broken shifter lever
- There is no age limit on stupidity
- ever had a slipping drive belt??
- Ironhead single clutch spring?
- Gear cover ?
- 4 Speed Trans
- Rigid_EVO 6-Speed Overdrive for your Sporty or Buell
- Belt Tention??
- Primary belt drive for XL's
- Chain Drive Pros/cons
- Rigid_EVO Ultima rite side 6 spd?
- Drive belt wear
- Best Clutch / Kit For A Performance Sportster?
- Pulled the 4 speed
- Plastic Cap on Transmission Output Shaft?
- final drive ratio
- Polyurethane Front Pulley for 4 Speed EVO
- SPROCKET & BELT SIZE? Difference 883 & 1200?
- cutting a drive belt to make thinner?
- Rubbermount_EVO Chain conversion kit for 05 883????
- Derby Cover Screw Heads Mangled
- Brown goo drained from primary
- Automatic primary adjuster
- chain sprockets
- Shifting noise/Clutch clunk/Rough shifting
- Clutch stack height?
- Rubbermount_EVO Clutch/Transmission Problem?
- Rubbermount_EVO My first trip inside the primary
- Best forward controls
- Ironhead good clutch basket bearing
- 2005 Sportster not Shifting into Gears...
- Ironhead 72 Sportster Clutch Adjustment
- Rubbermount_EVO attn: jockey shift owners
- HELP leaky troubles
- Well I need a clutch
- broken primary and missing parts??
- Please!! I Need Help With My Clutch
- Forward Controls Installation
- Shifting Qs
- Old drive belts
- Clutch slipping
- Barnett or Magnum cables?
- General Gear Ratio ?'s
- Rubbermount_EFI Front pulley for 2007's?
- stronger clutch
- clutch problem ?
- Odd thing in 1st gear
- Rubbermount_EVO Oil Leak Clutch Cable
- Need opinions on this...possibly tranny problem
- Belt vs Chain
- need help,primary oil change without changing oil filter
- Rigid_EVO Hydraulic clutch?
- Rubbermount_EVO Inspection cover gasket
- Rubbermount_EVO 2000 xl change belt drive to chain
- Which parts to order 883 Hugger
- Need help
- Rubbermount_EVO got the primary off--need some pointers
- Foot clutch and jockey shifter
- Rigid_EVO Tranny slip
- What size Belt?
- Ironhead Tranny install/shifting problem. Help Please!
- Still have right side noise
- Best Tire and size for 05 XL 1200 , Help !
- 92 rear pulley bolt pattern....
- clutch problem
- Clutch advice
- 1" belt in 1 1/8" pulley
- Tranny hard to shift
- Rigid_EVO 1995 Drian Line
- What rear sprocket with a front 24 tooth ?
- Rigid_EVO Advice about drivetrain
- Trans slip?
- Help me install a clutch lever
- Rubbermount_EVO Shifting, Shifter Problem
- Stuck in second gear??
- Rigid_EVO clutch/tranny not working...
- Primary Chain adjustment
- 08 1200C and clunking tranny
- This look like the right part?
- Easy Pull Clutch 08-09 sporty
- putting on forward controls and need some help
- Rubbermount_EFI what gear?
- strange chirpy noise from tranny
- Clutch Cable or Primary adjustment???
- Jockey Shift w/Mid Controls
- Ironhead jockey shift Q
- 4 speed clutch??
- Transmission Pulley Question 2002 Sporty
- Rigid_EVO Formula+ all over the garage floor
- Clutch for a nightster
- I need help, is my cluth going out at 40,000 miles?
- Rubbermount_EFI Clear Derby cover for sportster?
- Leak from shift arm HELP???
- pressure plate snap ring
- No power Transfer
- Rubbermount_EVO couple a questions about my clutch
- Rigid_EVO leaking out middle of sprcket
- Primary sight tube....
- pops out of second and more???
- 1200 vs 883 gearing
- Shavings on the primary drain plug
- Transmission trouble, I'm going in.
vBulletin® v3.8.5, Copyright ©2000-2013, Jelsoft Enterprises Ltd.